BrewBlog: Chad and Jack BB Imperial Stout
Specifics
General Information
Method: All Grain

This brew is Chad's and Jack's (Bemis) contribution of the Boreal Brewers 2012 Bourbon Barrel Imperial Stout.  Club members are brewing up 53 gallons to pour into a 53 gallon Jack Daniels oak barrel.  We're all trying to brew a similar recipe, and our's is really close to Buds.

We were a little light on the Roasted Barley, but decided to try to make it up with chocolate malt and switching from Crystal 90 to Crystal 120.

 

Comments

Pitched yeast from 2 starters, and 1 dry at 6:00pm  Very active fermentation by 8:30pm.  I put a blow off tube in right away.  I expect to see it pushing Kräusen by morning.

 

Scale Recipe
Enter desired final yield (volume):
 gallons  
Reference
Malts and Grains
30.00 pounds 66.5% of grist
1.75 pounds 3.9% of grist
3.00 pounds 6.6% of grist
1.63 pounds 3.6% of grist
3.00 pounds 6.6% of grist
3.00 pounds 6.6% of grist
2.00 pounds 4.4% of grist
0.75 pounds 1.7% of grist
45.13 pounds 100% of grist
Adjuncts
4.00 pounds Brown Sugar, Dark  
Non-Fermentables
2 tablets Whirlfloc @ 15 minutes  
3tsp Yeast Nutrient @ 15 minutes  
Reference
Hops
Reference
Yeast
Name: Safale
Manufacturer: Fermentis
Product ID: US-05
Type: Ale
Flocculation: Medium
Attenuation: 75-79%
Alcohol Tolerance: Medium
Temperature Range: 59–75°F
Mash Profile

Cereal Mash and Single Infusion Mash

Grain Temperature: 72°F Tun Temperature: 72°F
Sparge Temperature: 168°F PH: 5.4
Notes:

Boil cereal adjuncts to add to infusion mash.

Steps

# Name Type Time Temp. Description
1 Protein Rest Infusion 30 min. 104°F

Add 30% of mash water at 111° F / 44° C

2 Protein Rest Infusion 45 min. 122°F

Add 10% of mash water at 181° F / 83° C

3 Saccharification Infusion 60 min. 150°F

Add 25% of mash water at 200° F / 93° C

4 Mash Out Infusion 10 min. 168°F

Add 35% of mash water at 208° F / 98° C

Procedure

Made two 500 ML starters the day before.  Used a pack of Safale 05 in each.  They seemed to take off just fine, and produced a good yeast.  (This seemed evident by the fact that I had a good strong fermentation in the Ferminator just two hours later).

This was a huge grain bill for my equipment, but we did it anyway.  We ground it into two identical batches, of about 22.2 lbs per mash tun (we used my two 10 Gal water coolers).

Double Batch Sparge grains

  • two mash tuns each with half grain bill
  • 7 gallons mash water in each unit @ 155F
  • mashed for 1 hour
  • Collected 8 gallons of wort
  • rested grains 30 minutes
  • added 3.5  gallons to each for 2nd mash at 154
  • 2nd  mash for 30 minutes
  • Eat Pizza and watch football while mashing.Ravens beat the Oilers.
  • Collected 7 more gallons of wort

Pre-boil gravity was 1.075

The brewhouse efficiency was calculated to be about 67%.

Boil kettle could not hold all wort, so we boiled 13 gallons in main kettle and 2 gallons in smaller kettle.  Then we merged them at 30 minutes

Boiled exactly 70 minutes, first hops at 60.  Then 2nd hop addition at 30 minutes, and final hops at flame out.

Added 2 whirlflock tablets and 3 tsp of yeast nutrient at 15 minutes.

We carried the full boil kettle (14 gallons) to the side of my house where we let it rest/settle for 20 minutes.  It was 25F outside, so it wasn't going to spoil.  We sanitized up our equipment, and drained the wort through my plate chiller and into my Ferminator.  Gravity is one hell of a pump!.

Pitched our yeast starters, plus one pack of dry Safale 05, and oxygenated the heck out of it.

Collected a sample from the kettle drain hose, and determined the OG to be 1.097.

Success.

Special Procedures

I used a couple of hop bags for the first itme on this batch.  One bag held first and 2nd hop additions, and the other one for the final hop addition.  The bags really controlled the hop residue, but i am not sure how well the hops get used in the boil.  Tasting the wort after the boil suggested it worked ok.  Time will tell.

 

Tasting Reviews
1 Review Submit a Review Refresh Page
45-50 = Outstanding 30-37 = Very Good 14-20 = Fair
38-44 = Excellent 21-29 = Good 00-13 = Problematic
Review by
Aroma: / 12
Appearance: / 3
Flavor: / 20
Mouthfeel: / 5
Overall Impression: / 10
Cumulative Score: 0 / 50 Problematic
print logprint default Output to Beer XML
Chad's BrewBlogs
All Club BrewBlogs
RUZA Russian Imperial... Nov 30, 2014
Ravenwood IPA Oct 4, 2014
Ravenwood Rhubarb IPA May 26, 2014
Steamfitter Californi... Apr 19, 2014
Ravenwood IPA Mar 9, 2014
Ravenwood Russian Imm... Dec 23, 2013
Dervelde No 2 Nov 29, 2013
ipa Sep 13, 2013
<< <  More  [1] 2 3 4 5 > >>